Computational investigation of the effect of biodiesel fuel properties on diesel engine NOx emissions

Authors

  • Wenqiao Yuan
  • A. C. Hansen

Keywords:

Biodiesel, diesel engine modeling, NOx emissions

Abstract

A detailed numerical spray atomization, ignition, combustion and nitrogen oxides (NOx) formation model was developed for direct injection diesel engines by using KIVA3V code. Several modified or recalibrated sub-models including a Kelvin-Helmholtz Rayleigh-Taylor (KH-RT) spray breakup model, a Shell ignition model, a single-step kinetic combustion model and a Zel’dovich NOx formation model were incorporated into KIVA3V. This modified model was validated by experimental data obtained from a John Deere 4045T direct injection diesel engine that was fueled with a natural soybean methyl ester, a yellow grease methyl ester, a genetically modified soybean methyl ester and No.2 diesel fuel. Errors between predictions of the brake-specific NOx and measured values were less than 1% at full load. For biodiesel fuels, either the Zel’dovich mechanism overpredicted NOx emissions, the ratio of NO to NOx should be less than diesel fuel, or both. As observed from the modeling results, the higher latent heat of vaporization and higher surface tension of biodiesel relative to diesel fuel did not result in increased NOx emissions. The higher viscosity of biodiesel could be one of the reasons for increased NOx, but its effect was relatively small compared with the effect of decreased spray cone angle and advanced start of injection timing on NOx. Decreased spray cone angle and advanced start of injection were the main reasons for increased NOx emissions of biodiesel.
Keywords: biodiesel, diesel engine modeling, NOx emissions
DOI: 10.3965/j.issn.1934-6344.2009.02.041-048


Citation: Yuan W, Hansen A C. Computational investigation of the effect of biodiesel fuel properties on diesel engine NOx emissions. Int J Agric & Biol Eng, 2009; 2(2): 41

Downloads

Published

2009-06-30

How to Cite

Yuan, W., & Hansen, A. C. (2009). Computational investigation of the effect of biodiesel fuel properties on diesel engine NOx emissions. International Journal of Agricultural and Biological Engineering, 2(2), 41–48. Retrieved from https://www.ijabe.migration.pkpps06.publicknowledgeproject.org/index.php/ijabe/article/view/83

Issue

Vol. 2 No. 2 (2009): IJABE

Section

Renewable Energy and Material Systems

License

IJABE is an international peer reviewed, open access journal, adopting Creative Commons Copyright Notices as follows.

Authors who publish with this journal agree to the following terms:

  1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
  2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
  3. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).